Support User Manuals

Invacare Pronto M61 Mobility Aid User Manual

Open as PDF

of 80

SECTION 11—BATTERIES

Pronto® M51™and M61™with SureStep® 62 Part No 1125085

NOTE:Forthisprocedure,refertoFIGURE 11.2onpage 63.

NOTE:Ifthereisbatteryacidinthebottomofthebatterytrayoronthesidesofthebattery,apply

bakingsodatotheseareastoneutralizethebatteryacid.Beforereinstallingtheexistingornew

battery,cleanthebakingsodafromthebatterytrayorbatterybeingsuretoavoidcontactwithskin

andeyes.Determinesourceofcontamination.NEVERinstall/reinstallabatterywithacrackedor

otherwisedamagedcase.

NOTE:Havethefollowingtoolsavailable:

Removing

1. Placethewheelchairinawellventilatedareawhereworkcanbeperformedwithout

riskingdamagetocarpetingorfloorcovering.

2. VerifythejoystickOn/OffswitchisintheOffpositionanddisconnectjoystickcable

(notshown).RefertoDisconnecting/ConnectingtheJoystickonpage 121.

3. Removetheseat.Refertooneofthefollowingprocedures:

•VanSeats‐RefertoRemoving/InstallingtheSeatAssemblyonpage 48.

•ASBASeats‐RefertoRemoving/InstallingtheSeatAssemblyonpage 57.

4. Removethetopshroud.RefertoRemoving/InstallingtheTopShroudonpage 85.

5. Disconnectthefrontbatteryfromthecontroller(BLACKconnector).

6. Disconnecttherearbatteryfromthefrontbattery(REDandBLACKconnectors).

7. Liftrearandfrontbatteryoutofthebatterytrayusingthebatteryhandles.

Installing

1. VerifythejoystickOn/OffswitchisintheOffpositionanddisconnectjoystickcable.

RefertoDisconnecting/ConnectingtheJoystickonpage 121.

2. Positionthefrontbatteryinthefrontofthebatterytray.

3. Positionrearbatteryinrearofbatterytray.

NOTE:Ensurethatbothbatteriesareproperlyseatedandrestingonthebatterytray.

4. Connecttherearbatterytothefrontbattery(REDandBLACKconnectors).

5. Connectthefrontbatterytothe

controller(BLACKconnector).

6. Reinstallthetopshroud.RefertoRemoving/InstallingtheTopShroud

onpage 85.

7. Reinstalltheseat.Refertooneofthefollowingprocedures:

•VanSeats‐RefertoRemoving/InstallingtheSeatAssembly

onpage 48.

•ASBASeats‐RefertoRemoving/InstallingtheSeatAssemblyonpage 57.

TOOL QTY COMMENTS

7/16-INCH (6PT) BOX WRENCH 1 Not Supplied

DIAGONAL CUTTERS 1 Not Supplied

previous next