Support User Manuals

Invacare RPS350-2 Mobility Aid User Manual

Open as PDF

of 40

MAINTENANCE

Stand Up Lift Model RPS350-2 32 Part No. 1145811

TheInvacareStandUpLiftisdesignedtoprovideamaximumofsafe,efficientand

satisfactoryservicewithminimumcareandmaintenance.

Allpartsofthestandupliftaremadeofthebestgradesofsteel,butmetaltometalcontact

willwearafterconsiderableuse.

Thereisnoadjustmentormaintenanceofeitherthecastersorbrakes,otherthancleaning,

lubricationandcheckingaxleandswivelboltsfortightness.Removealldebris,etc.from

thewheelandswivelbearings.Ifanypartsareworn,replacethesepartsimmediately.

Ifyouquestionthesafetyofanypartofthelift,contactyourdealerimmediatelyand

advisethemoftheproblem.

Lubricating the Lift

NOTE:Forthisprocedure,refertoFIGURE 7.1.

TheInvacareliftisdesignedforminimummaintenance.However,asixmonthcheckand

lubricationshouldensurecontinuedsafetyandreliability.

Keepliftandslingscleanandingood

workingorder.Anydefectshouldbenoted

andreportedtoyourdealerassoonas

possible.

ThecastersMUSTswivelandroll

smoothly.Alightgrease(waterproofauto

lubricant)maybeappliedtotheball

bearingswivelofthecastersonceayear.

Applymorefrequentlyifthecastersare

exposedtoextrememoistconditions.

Lubricateallpivotpoints.Wipeallexcess

lubricantfromliftsurface.

FIGURE 7.1 Lubricating the Lift

Detecting Wear and Damage

Itisimportanttoinspectallstressedparts,suchasslings,spreaderbarandanypivotfor

slingsforsignsofcracking,fraying,deformationordeterioration.Replaceanydefective

partsimmediatelyandensurethattheliftisnotuseduntilrepairsaremade.

Cleaning the Sling and the Lift

Theslingshouldbewashedregularlyinwatertemperatureof180°F(82°C)anda

biologicalsolution.Asoftcloth,dampenedwithwaterandasmallamountofmild

detergent,isallthatisneededtocleanthestanduplift.Theliftcanbecleanedwithnon‐

abrasivecleaners.

Caster

previous next