Filter
Top Products
39
Celebrity XL www.pridemobility.com
DRIVE WHEEL
NUT
WHEEL REPLACEMENT
If your scooter is equipped with pneumatic tires and
you have a flat tire, you can have the tube replaced.
If your scooter is equipped with a solid tire insert,
either the solid insert or the entire wheel must be
replaced depending on the model. Contact your
authorized Pride Provider for information regarding
replacement wheels for your scooter.
WARNING! Wheels on your scooter
should only be serviced/replaced by
an authorized Pride Provider or quali-
fied technician.
WARNING! Completely deflate pneu-
matic tires before dismantling the
rim or attempting repair.
WARNING! Be sure that the key is
removed from the key switch and the
scooter is not in freewheel mode
before performing this procedure.
WARNING! When changing a tire,
remove only the center lug nut, then
remove the wheel. If any further dis-
assembly is required, deflate the tire
completely or it may explode.
Follow these easy steps for a quick and safe repair
of both pneumatic and solid tires:
1. Remove the key from the key switch.
2. Elevate the side of the scooter from which you
are removing the tire. Place wooden blocks under
the frame to elevate the scooter.
3. If you are changing a pneumatic tire, completely
deflate it before removing the wheel.
4. Remove the drive wheel nut and washer from the
axle. See figure 25.
5. Pull the wheel off the axle.
6. Remove the nuts and washers and separate the
rim halves. See figure 26.
7. Remove the old tube from the pneumatic tire and replace it with a new tube or replace the entire
assembly if it is a solid tire.
8. Reassemble the rim halves.
9. Slide the wheel back onto the axle. Make sure that the axle key is in the axle slot. See figure 25.
WARNING! Failure to ensure that the axle key is properly installed into the axle slot
when mounting the wheel can result in electronic brake failure, personal injury, and/or
product damage.
Figure 25. Drive Wheel Removal
Figure 26. Drive Wheel Assembly
IX. CARE AND MAINTENANCE
DRIVE WHEEL WASHER
AXLE KEY
HUB
REAR RIM HALF
TIRE
TUBE
WARNING! Completely deflate
the tire before attempting repair!
HUB
REAR RIM HALF
TIRE
TUBE
FRONT
RIM
HALF
WASHERS
NUTS