Filter
Top Products
TROUBLESHOOTING
Electric Portable Patient Lift 34 Part No. 1145810
SECTION 6— TROUBLESHOOTING
NOTE:Ifproblemsarenotremediedbythesuggestedmeans,pleasecontactyourdealeror
Invacare.
SYMPTOMS FAULTS SOLUTION
Patient lift feels loose. Mast/base joint loose.
Tie - Rods are loose.
Refer to Installation on page 17.
Refer to Maintaining the Base Adjustment on
page 39.
Casters/Brakes noisy or stiff. Fluff or debris in bearings. Refer to Replacing Casters/Forks
on page 40.
Noisy or dry sound from pivots. Needs lubrication. Refer to Lubricating the Lift
on page 36.
Actuator fails to lift or legs fail to
open when button is pressed.
Hand-control or actuator con-
nector loose.
Battery low.
RED emergency stop button
pressed IN.
Battery not connected prop-
erly to control box.
The connecting terminals are
damaged.
Boom or leg actuator in need
of service or load is too high.
Charge batteries. Refer to Charging the Battery
on page 24.
Rotate RED emergency stop button CLOCK-
WISE until it pops out.
Reconnect the battery to the control box. Refer
to Charging the Battery
on page 24.
Replace the battery pack. Refer to Charging the
Battery on page 24.
Refer to Replacing the Boom Actuator
on page 37
or Installing the Leg Actuator to the Base on
page 19. Contact your dealer.
Unusual noise from actuator. Actuator is worn or damaged
or spindle is bent.
Refer to Replacing the Boom Actuator
on page 37
or Installing the Leg Actuator to the Base
on
page 19. Contact your dealer.
Lift arms will not lower in upper-
most position.
Lift arms require a minimum
weight load to lower from the
uppermost position.
Pull down slightly on the lift arms.
Lift arms will not lower during a
power retraction.
Shoulder bolt at the junction of
the boom and mast may not be
properly installed.
Refer to Checking and Tightening Mast Pivot Bolt
on page 38.