A SERVICE OF

logo

Open as PDF
next previous
5
*ChargeRatesforthismodelarelistedonthe
front panel.
**Based on battery at 50% charge.
AH AmpereHours
NR NotRecommended
CCAColdCrankingAmps
RC ReserveCapacity
MC MarineCapacity
BATTERY SIZE/RATING CHARGE RATE*/CHARGING TIME - HOURS**
2 AMP 10 AMP 30 AMP 35 AMP 50 AMP 60 AMP
SMALL
BATTERIES
Motorcycle, Garden
Tractor, etc.
6-12AH 1.5 to 3 NR NR NR NR NR
12-32AH 3 to 8
CAR/TRUCKS 200-315CCA 40-60RC 11 to 15 2.5 to 3 .75 to 1 .5 to .75 NR NR
315-550CCA 60-85RC 15 to 18 3 to 4 1 to 1.5 .75 to 1 .5 to .75 .5 to .63
550-875CCA 85-125RC 18 to 25 4 to 5 1.5 to 1.7 1 to 1.5 .75 to 1 .63 to .75
MARINE/
DEEPCYCLE
55MC 15 4 NR NR NR NR
80MC 19 5 2 1.75 NR NR
105MC 23 6 2.5 2 NR NR
L. ASSEMBLY INSTRUCTIONS
Wheel Charger Assembly Instructions: (Instrucciones De Armado)
NOTE:Chargermustbeassembledbeforeoperating(Antedelaoperaciónlaunidaddebeestararmada)
Parts (Piezas)
(2)10-32screws (tornillosdecorterosca10-32) 5/16"wrench (Llavede5/16")
(2)1/4-20screws (tornillodecorterosca1/4-20) 3/8"wrench (Llavede3/8")
(2)wheels (ruedas) Hammer (Martillo)
(2)axlecaps (tapasdeleje) Screwdriver (Destornillador)
(1)handle (mango)
(1)mountingfoot (pedestaldemontaje)
(1)axle (deleje)
Tools necessary (Herramientas Necesarias)
1.Firstplacethechargeronitside.
2.NextmountthemountingfootFIG.Awith(2)1/4-20screws,orFIG.Fwith(2)10-32screws.
3.NextpoundtheaxlermlyintoanaxlecapusingahammerFIG.B.
4. Slideonewheelontotheaxlewithhubfacingin,asshowninFIG.C.
5.Pokeaboveassemblythruholesinchargerbackuntilaxlesticksoutoftheotherend.
6. Turn charger on its other side.
7.Slidewheelandpoundcapontotheaxleend.
8. Next turn the charger right side up onto its foot and wheels.
9.Removethe(2)topscrewsfromeachsideofthecharger,lineupthehandleandreinstallthescrewsFIG.E.
Primerocoloqueelcargadordelado.
AcontinuaciónmonteelpedestalFIG.Acon(2)tornillos1/4-20.
Acontinuacióngolpeermementeelejedentrodelatapadelejeusandounmartillo,FIG.B.
Acontinuacióndeslicelasruedasdentrodeleje;loscubosdebenestarorientadoshaciaadentro,FIG.C.
Acontinuacióngolpeelaotratapadelejedentrodelotroextremedeleje.
AcontinuacióncoloqueelconjuntodelejedentrodelfondodelcargadorsegúnsemuestraenlaFIG.C.
Monteelejeenelfondodelcargadorusandolosdostornillodecortederosca10-32segúnsemuestraenlaFIG.D.
Acontinuacióngireelcargadordelabateríaconelladoderechohaciaarribasobresupedestalyruedas.
Saquelosdostornillossuperioresdecadaladodelcargador;alineeelmangoyreinstalelostornillo.FIG.E.
Fig.E
Fig.F
Fig.B
AXLECAP
Fig.A
Fig.D
AXLEBRACKET
HUBSMUST
FACEIN
Fig.C
TROUBLESHOOTING
Ifaproblemdoesoccur,checkthefollowing:
PROBLEM POSSIBLE CAUSE SOLUTION
NoMeterReading(ACCordUnplugged) Clipsarenotmakingagoodconnection.
Battery voltage is too low.
2ampchargeratebeingused
Rock clips back and forth for a better connection.
PlugAClineintooutlet.Metershouldnowindicate.
None,meterwillnotindicatehere.
Chargerwillnotturnonwhenproperly
connected.
ACoutletisdead.
Poor electrical connection.
Pluginalamptocheckforvoltage.
Checkconnections,rockbackandforthforabetter
connection.
Clickingnoisefromcharger. Circuitbreakeriscycling.
Battery is defective.
Severelydischargedbatterybutotherwiseagood
battery.
Reverse connections at battery.
May be in the wrong switch position.
HaveBatterychecked.
Allow charging to continue until battery has a chance to
recoversufcientlytotakeacharge.Ifmorethat20min.
stop charging and have the battery checked.
Shutoffchargerandcorrectleadconnections.