Filter
Top Products
22 Iss 4
Routine maintenance
The following table gives an indication as to when routine maintenance checks should be made.
SIX MONTHLY
ANNUALLY
Storage
When storing your Scoota for long periods (in
excess of one week), charge batteries for 24 hours
and then disconnect the batteries to minimise
battery discharge.
Electronic faults
Do not attempt to investigate faults in the control
box, the control pod or charger as the design and
set up of the electronics is of a safety critical
nature.
Spare parts are available from authorised
Sunrise Dealers.
Replacing bulbs
Caution! Disconnect batteries before changing
bulbs.
Indicators 24v 5w
Rear lights 24v 5w
Headlight 24v 18w
Always replace the bulbs with the correct rating or
incorrect operation will result.
Wheels
N.B. Wheels should only be removed and refitted by
a Sunrise dealer, ensure that the nuts are replaced with
Sunrise nuts.
Battery charge check (Fig. D)
Look at battery charge indicator on tiller before use to ensure batteries are
fully charged.
Inspection of connectors (Fig. C)
Remove rear panel and ensure all connectors are secure.
Wipe over with a damp cloth
Use only a damp soft cloth and mild detergent on panels, tiller and seat.
Check tyre pressure
Please use a footpump with pressure gauge to inflate tyres and/or a tyre
gauge to check pressure. Each tyre should be inflated to 207 kilopacals (30psi).
Long overnight battery charge
Please ensure that the batteries are charged for a minimum of 8 hours.
Check tyres for wear (See Fig. A and Fig. B)
Look at the tyres to ensure that the tread is visible and continuous.
The checks below must be carried out by an authorised Sunrise dealer
Seat swivel, seat slide (where fitted)
Inspection of wiring for chafing and wear
Battery terminals
Clean and protect with petroleum jelly.
Ensure parking brake (where fitted) is correctly adjusted
Check stabiliser wheels for wear
Inspect motor brushes
Full service by dealer
The checks below can be carried out by the user
Daily
Weekly
Monthly
Quarterly
Six Monthly
Annually
Fig. A
Fig. B
There is no service manual available.
Maintenance, fault finding and servicing should be carried out by
an authorised Sunrise dealer unless otherwise indicated.
Fig. C
Fig. D
4
7