Braun NUVL855R Wheelchair User Manual


  Open as PDF
of 32
 
Page 6
Terminal Strip and Door Operators
3RZHU'RRU2SHUDWRUV
Black
Jumper
1 2345678910
Terminal Strip
The pump-mounted terminal
strip provides additional inputs
and outputs that can be used
for optional door operators,
beepers, interlocks, etc. - as
well as the door safety switch.
The black jumper wire must be
installed in terminals 6 and 9
to supply power to the circuit
board.
C_SW
1
O_RL
2
N/C
3
IN_LK
4
12_V
5
PWR
6
GND
7
F_LV
8
O_SW
9
C_RL
10
To Door Openers
“Close” Trigger
To Door Openers
“Open” Trigger
Full Open
Orange
Red
Door Cutout
Black
Blue
Install optional power
door operators as
detailed in the instruc-
tions supplied with
door operator kit.
Route the wires to
the pump module and
connect to the termi-
nal strip as shown.
Floor Level and Inner Roll Stop Adjustments
$FKLHYLQJSURSHUÁRRUOHYHOSRVLWLRQLQJRIWKHSODW-
form and inner roll stop requires a combination of
)ORRU/HYHOVZLWFKDGMXVWPHQWDQGLQQHUUROOVWRS
adjustment. Both are factory set but must be in-
spected during installation procedures (will vary per
vehicle application).
Ensure the lift is positioned and secured as speci-
ÀHGRQ4XLFN5HIHUHQFH,QVWDOODWLRQ6KHHWVXS-
plied with lift) panels 1 and 2. Adjust the Floor
Level switch ÀUVW(detailed below). Then, adjust
the inner roll stop as detailed in Inner Roll Stop
Adjustment Instructions (adjust only if necessary).
The inner roll stop must rest properly on the vehicle
ÁRRUIRUZKHHOFKDLUHQWU\DQGH[LW
7KH)ORRU/HYHOVZLWFKVWRSVXSZDUGWUDYHORIWKH
platform during the Up function (activated by the
WRUTXHWXEHPRXQWHG)ORRU/HYHOFDP
Position the bottom of the lift platform 1 1/2" above
ÁRRUOHYHOWKUHVKROGPDWusing the manual op-
eration system. 'RQRW operate the lift with the
electric pump during adjustment procedures.
Loosen the clamp securing the torque tube-mount-
HG)ORRU/HYHOFDP5RWDWHWKHFDPXQWLOWKH)ORRU
Level switch is activated (cam depresses switch).
1RWH&KHFNWKHÁRRUOHYHOSRVLWLRQRIWKHSODWIRUP
and the inner roll stop after powering the pump.
Hydraulic pressure may affect platform height
VOLJKWO\)LQHWXQLQJDGMXVWPHQWWZHDNLQJRIWKH
)ORRU/HYHOVZLWFKPD\EHUHTXLUHG
Floor Level Switch Adjustment
Adjust the Floor Level switch ÀUVW
(before adjusting the inner roll stop)!
)ORRU/HYHO6ZLWFK
)ORRU/HYHO&DP
Torque Tube
A
Cam depressing switch.
 previous next