Filter
Top Products
APOLLO 60 HP SUPPLIED-AIR RESPIRATOR
x 04440 Flow Regulator
x 04410 Flow Regulator
x 04411 Flow Regulator
x 21422 Cont. Flow Conn.
x 04397 Hose 25 Ft.
x 04415 Hose 50 Ft.
x 04398 Hose 100 Ft.
Page 1
Clemco Industries Corp.
Washington, Missouri USA
(314) 239-0300
TYPE C AND CE CONTINUOUS FLOW SUPPLIED-AIR RESPIRATOR IS APPROVED
ONLY IN THE FOLLOWING CONFIGURATIONS:
TC#
19C-130
APL
SA
1 PROTECTION
SA-Supplied -air
2 CAUTIONS AND LIMITATIONS
B-Not for use in atmospheres immediately dangerous to life or
health.
C-Do not exceed maximum use concentrations established by
regulatory standards.
D-Air-line respirators can be used only when the respirators are
supplied with respirable air meeting the requirements of
CGA G-7.1 Grade D or higher quality.
E-Use only the pressure ranges and hose lengths specified
in the user's instructions.
J- Failure to properly use and maintain this product could
result in injury or death.
M-All approved respirators shall be selected, fitted, used, and
maintained in accordance with MSHA, OSHA, and other
applicable regulations.
N-Never substitute, modify, add, or omit parts. Use only exact
replacement parts in the configuration as specified by the
manufacturer.
O-Refer to users instructions, and/or maintenance manuals for
information on use and maintenance of these respirators.
S-Special or critical users instructions, and/or specific use
limitations apply. Refer to instruction manual before donning.
B C D E J N O S
MODEL
PROTECTION
1
Cautions and
Limitations
2
Components
Alternates
1.0 INTRODUCTION
1.1 Scope of manual
1.1.1 This manual covers setup, operation, mainte-
nance, replacement parts, and important warnings for safe
operation of the Clemco Apollo 60 HP Supplied-Air Respi-
rator.
1.1.2 OSHA requires the employer to establish a com-
prehensive respiratory protection program per regulations
29 CFR 1910.134(a)(b) and 29 CFR 1926.103, to include
the following:
1. Program coordination by a designated
responsible individual.
2. Evaluation of each worker’s ability to perform
the work while wearing a respirator.
3. Periodic training.
4. Periodic environmental monitoring.
5. Respirator-fit testing.
6. Maintenance, inspection cleaning, and
storage of the respirators.
7. Selection of the proper NIOSH-approved
respirator.
1.1.3 For safe use of the respirator, it is essential that
the user be properly instructed in its use and maintenance.
This manual must be made available to all users of the
respirator. [Reference OSHA Regulations 1910.134.] Read
the entire manual before installing or operating the equip-
ment.
1.1.4 The respirator must be supplied with respirable air
meeting requirements described herein. It is the responsi-
bility of the owner to provide quality breathing-air to the
respirator, and to establish a program to ensure that the
respirator is properly used and maintained.
1.1.5 The following manuals are available for accesso-
ries that may be used in conjunction with the Apollo
Respirator.
Description Manual No.
CAT Cool-Air Tube 08956
CCT Climate Control Tube 08850
CPF Particulate Air Filter 04143
ABL 4021 CarbonMonoxide Alarm 21457
1.2 Hazard Alerts
1.2.1 Clemco uses signal words, based on ANSI Z535.2-
1991, to alert the user of a potentially hazardous situation
that may be encountered while operating this equipment.
ANSI’s definitions of the signal words are as follows:
! NOTICE
“Notice” is used to indicate a statement of com-
pany policy as the message relates directly or
indirectly to the safety of personnel or protection
of property.
! CAUTION
“Caution” is used to indicate a potentially hazard-
ous situation which, if not avoided, may result in
minor or moderate injury.
x 10506 Helmet