SIDEWINDER PG. 11
IMPORTANT SAFETY INSTRUCTIONS
READ and UNDERSTAND all instructions and
warnings before operating this machine!
Operate only in well ventilated areas.
Buildings must be provided with:
A. A continuous mechanical ventilation that
removes the products of combustion to the
outdoors of not less than 300 CFM for each
10,000 BTUH or fraction thereof; or
B. Natural ventilation of not less than 300
CFM for each 10,000 BTUH input or
fraction thereof, based on a maximum of
one-quarter air exchange per hour for the
net building volume.
If you smell LPG gas, stop the unit and check
for leaks. Also open windows, don’t touch
electrical switches, extinguish any open
flames. Call your gas supplier if no leaks
are found.
Do not adjust the fuel system without the
proper analysis equipment.
Never tilt the equipment on its side for pad, belt
or brush replacement. It is designed to tilt back
on its rear wheel and handle for maintenance
and repair. A second person should aid in
lifting and securing equipment for repair.
Never tilt & transport while engine is running.
Keep hands and feet clear of all moving parts.
Never try to replace parts or repair equipment
with machine running.
Turn the gas off at the tank to kill the engine.
Remove the LPG tank and store it in an
approved area when not in use. A “NO
SMOKING” sign should be permanently
displayed at the storage area.
Always vent an over-full bottle using thetank’s
bleedvalve,out ofdoorsawayfrom allclosed
placesandawayfromanyfireor flameproducing
device.Vent until the whitevapor turns clear.
Keep all objects clear of the exhaust system
during and after operation.
Do not leave this machine unattended while the
engine is running.
Do not operate equipment in one location for
more than a few seconds. Damage to floor
surface can occur.
Always store equipment away from possible
damage by falling objects in warehouse-type
areas. Always store LPG tanks outside in a
secure, well-ventilated area.
When the LPG tank is attached to the machine
and not running, the operator should not leave
the machine unattended except for short periods
of time such as rest stops, washroom or meal
stops.
The operator must completely understand
all instructions, warnings and operating
procedures before using this machine.
The manufacturer’swarranty will be voided if
the machine is not maintained in accordance
with this manual’s recommended maintenance
instructions and the engine manufacturer’s
recommended maintenance procedures.
Failure to do so may cause damage to the
machine, equipment, furniture, buildings or
personal injury!
A maintenance record shouldbe kept indicating
date of service, hours on engine,and work done.
TRANSPORTING THE MACHINE
NEVER TRANSPORT WHILE ENGINE IS
RUNNING!
To transport the machine it is necessary to tilt
the machine back on the rear wheels so the
brushes (or pads) are not in contact with the
PG. 2 SIDEWINDER
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this machine. Always store
equipment away from heater rooms,
boilers, gas-fired water heaters or any
other source of open flame. Propane is
highly flammable. Always store LPG tanks
(full or empty) outside in a secure, well
ventilated area.
NO SMOKING, NO SPARKS, NO FLAMES
NEAR UNIT OR LPG TANK.
WARNING!
!
Follow the instructions givenin this booklet,
the Engine’s Owners Manualand the training
given by your supervisor for thesafe operation
of this machine. Failureto do socan result in
personal injury and/ordamage to themachine
or property.
DO NOT OPERATE THIS MACHINE IN AN
EXPLOSIVE ENVIRONMENT!
THIS PROPANE MACHINE IS INTENDED FOR
COMMERCIAL USE.
WARNING!
!
WARNING!
!
KAWASAKI 13 HP ENGINE PARTS
PART # DESCRIPTION PART # QTY
1 FOAM HAT FILTER 186-271964 1
2 DEBRIS SCREEN 309-18540 1
3 FOAM HAT SEAL 175-7.75*9.25*1 1
4 OIL PRESSURE SWITCH
12vSTARTER MODEL 152-N3-0082 1
110v STARTER MODEL 309-27010-7002 1
5 OIL FILTER 309-49065-2078 1
6 OIL DRAINVALVE 312-504-0185 1
7 1/4"* 1 1/4KEY 199-NHNT-SE UND 1
8 CENTRIFUGAL CLUTCH 311-180007 1
9 EXH. MANIFOLD GASKET 309-110607006 1
10 MUFFLER-MANIFOLD COMBO (1 PC) 152-EM-02 1
11 FOAM PRE-FILTER 309-11013-7016 1
12 AIRFILTER ELEMENT 309-11013-7017 1
KAWASAKI 17 HP ENGINE PARTS
PART # DESCRIPTION PART # QTY
1 FOAM HAT FILTER 186-271964 1
2 DEBRIS SCREEN 309-18540 1
3 FOAM HAT SEAL 175-7.75*9.25*1 1
4 OIL PRESSURE SWITCH 152-N3-0082 1
5 OIL FILTER 309-49065-2078 1
6 OIL DRAINVALVE 312-504-0185 1
7 1/4"* 1 1/4KEY 199-NHNT-SE UND 1
8 CENTRIFUGAL CLUTCH 311-180009 1
9 EXH. MANIFOLD GASKET 309-110607006 1
10 EXHAUST MANIFOLD 152-KAWMAN 1
11 CATALYTICMUFFLER 309-KMUFFLER
12 FOAM PRE-FILTER 309-11013-7001 1
13 AIR FILTER ELEMENT 309-11013-7006 1
